卡特C系列挖掘机发动机故障代码表

Flash CodeSPN (1)/FMI CodeDiagnostic Code or Event Code Description of Code 挖掘机维修

13 174-03174-03Fuel Temperature open/short to +batt 燃油温度传感器或线路故障

174-04174-04 Fuel Temperature short to groun燃油温度传感器或线路故障挖掘机维修,挖掘机修理,维修挖掘机,修理挖掘机

挖掘机修理16626-052417-05Ether Injection Control Solenoid open/short to +batt乙醚喷射控制电磁阀或线路故障

626-062417-06Ether Injection Control Solenoid short to ground 乙醚喷射控制电磁阀或线路故障

21678-0341-038 Volt DC Supply short to +batt 8V直流电源故障

678-0441-048 Volt DC Supply short to ground 8V直流电源故障

620-03262-035 Volt Sensor DC Power Supply short to +batt 5V直流电源故障

1079-03620-04262-045 Volt Sensor DC Power Supply short to ground 5V直流电源故障

1079-0424100-03100-03 Engine Oil Pressure open/short to +batt 机油压力传感器或线路故障

100-04100-04Engine Oil Pressure short to ground机油压力传感器或线路故障

100-10100-10 Engine Oil Pressure abnormal rate of change机油压力更新率不正常

25 102-03102-03Boost Pressure Sensor short to +batt增压压力传感器或线路故障

102-04102-04Boost Pressure Sensor short to ground增压压力传感器或线路故障

102-10102-10Boost Pressure Sensor abnormal rate of change增压压力更新率不正常

102-031785-03Intake Manifold Pressure Sensor voltage above normal进气压力传感器电压高于正常值

102-041785-04Intake Manifold Pressure Sensor voltage below normal 进气压力传感器电压低于正常值

102-101785-10Intake Manifold Pressure Sensor abnormal rate of change 进气压力更新率不正常

26108-03274-03Atmospheric Pressure open/short to +batt大气压力传感器或线路故障

108-04274-04Atmospheric Pressure short to ground大气压力传感器或线路故障

27110-03110-03 Engine Coolant Temperature open/short to +batt冷却液温度传感器或线路故障

110-04110-04Engine Coolant Temperature short to ground冷却液温度传感器或线路产

2891-1391-13Throttle Position calibration require油门需要校准

3291-0891-08Throttle Position signal abnormal油门信号不正常

34 190-08190-08Engine Speed signal abnormal发动机转速信号不正常

723-08 342-08 Secondary Engine Speed signal abnormal备用发动机转速信号不正常

35190-15E362 (1) Engine Overspeed Warning发动机超速报警

190-00E362 (3) Engine Overspeed Shutdown发动机超速停机

37 94-0394-03Fuel Pressure open/short to +batt燃油压力传感器或线路故障

94-0494-04Fuel Pressure short to ground燃油压力传感器或线路故障

38105-03172-03Intake Manifold Air Temp open/short to +batt进气温度传感器或线路故障

105-04172-04Intake Manifold Air Temp short to ground进气温度传感器或线路故障

42637-13261-13Engine Timing calibration required发动机正时需校准

46100-17E360 (1) Low Engine Oil Pressure Warning机油压力低报警

100-18E360 (2) Low Engine Oil Pressure Derate机油压力低降载

100-01 E360 (3) Low Engine Oil Pressure Shutdown机油压力低停机

51168-00168-00System Voltage hig系统电压高

168-01168-01System Voltage low系统电压低

168-02168-02System Voltage intermittent/erratic 系统电压不正常

56630-02268-02 Check Programmable Parameters发动机参数设置需检查

58 639-09247-09 J1939 Data Link communications J1939数据链接故障

61110-15 E361 (1) High Engine Coolant Temperature Warning冷却液温度高报警

110-16E361 (2) High Engine Coolant Temperature Derate 冷却液温度高降载

110-00 E361 (3) High Engine Coolant Temperature Shutdown冷却液温度高停机

62 111-17 E2143 (1) Low Engine Coolant Level Warning冷却液位低报警

111-18E2143 (2) Low Engine Coolant Level Derate冷却液位低降载

111-01E2143 (3) Low Engine Coolant Level Shutdown冷却液位低停机

6394-15E096 (1) High Fuel Pressure Warning燃油压力高报警

64 1636-15E539 (1) High Inlet Air Temperature Warning进气温度高报警

1636-00E539 (3) High Inlet Air Temperature Shutdown进气温度高停机

65 174-15E363 (1) High Fuel Temperature Warning燃油温度高报警

174-16E363 (2) High Fuel Temperature Derate 燃油温度高降载

174-00 E363 (3) High Fuel Temperature Shutdown燃油温度高停机

670441-15E445 (1) High Auxiliary Temperature Warning辅助温度高报警

0441-16E445 (2) High Auxiliary Temperature Derate辅助温度高降载

0441-00 E445 (3) High Auxiliary Temperature Shutdown辅助温度高停机

0441-031836-03Auxiliary Temperature Sensor open/short to +batt 辅助温度传感器或线路故障

0441-041836-04Auxiliary Temperature Sensor short to ground辅助温度传感器或线路故障

681387-15E443 (1) High Auxiliary Pressure Warning辅助压力高报警

1387-16 E443 (2) High Auxiliary Pressure Derate辅助压力高降载

1387-00E443 (3) High Auxiliary Pressure Shutdow辅助压力高停机

1387-031835-03 Auxiliary Pressure Sensor open/short to +batt辅助压力传感器或线路故障

1387-041835-04 Auxiliary Pressure Sensor short to ground辅助压力传感器或线路故障

71 651-05001-05Cylinder #1 Injector open circuit1缸喷油器故障

651-06 001-06Cylinder #1 Injector short 1缸喷油器故障

72652-05002-05Cylinder #2 Injector open circuit 2缸喷油器故障

652-06002-06Cylinder #2 Injector short 2缸喷油器故障

73 653-05003-05Cylinder #3 Injector open circuit 3缸喷油器故障

653-06003-06Cylinder #3 Injector short 3缸喷油器故障

74 654-05004-05Cylinder #4 Injector open circuit 4缸喷油器故障

654-06004-06 Cylinder #4 Injector short 4缸喷油器故障

75 655-05005-05Cylinder #5 Injector open circuit 5缸喷油器故障

655-06 005-06 Cylinder #5 Injector short 5缸喷油器故障

76656-05 006-05Cylinder #6 Injector open circuit 6缸喷油器故障

656-06006-06Cylinder #6 Injector short6缸喷油器故障

挖掘机技术故障与师傅进行沟通交流，官方网站http://www.yajcwx.com修理直拨:0551-64493367  服务专线:13956953738